Е-Публикации
Технически университет - София

Abstract: Carbon dioxide (CO2/R744) is a natural refrigerant that has been widely studied as a replacement for conventional hydrofluorocarbon-based refrigerants in HVAC&R systems. However, the performance of CO2 heat pumps depends strongly on the system architecture, component parameters, operating conditions, and pressure control. This study examines a CO2-based heat pump integrated into an AHU with two-stage heat recovery. Heat recovery from the exhaust air is initially performed using a regenerative sorption wheel and then in an R744 heat pump with fin-and-tube heat exchangers located directly in the airflows. The operating performance of the heat pump was evaluated through system-level simulation based on commercially available component data and iterative balancing of the refrigeration cycle and air-side processes. For the investigated configuration and selected components, the proposed R744 system is compared with a conventional R410A-based reference system under the same air-side boundary conditions. Therefore, this comparison is interpreted as a system-level benchmark rather than an isolated effect of the refrigerant itself, since performance depends on the refrigerant’s properties, compressor performance, heat exchanger configuration, system architecture, and the operating limitations of the components. Simulations are performed for both heating and cooling modes, while preliminary experimental measurements from a physical prototype are presented for qualitative comparison with the simulated heating-mode trend.

References

1. European Commission Regulation (EU) No. 573/2024 of the European Parliament and of the Council of 7 February 2024 on Fluorinated Greenhouse Gases, Amending Directive (EU) 2019/1937 and Repealing Regulation (EC) No. 517/2014. 2024, OJ L 2024/573, Document 32024R0573 Available online: https://eur-lex.europa.eu/eli/reg/2024/573/oj/eng (accessed on 23 March 2026)
2. ANSI/ASHRAE Designation and Safety Classification of Refrigerants Addendum to ANSI/ASHRAE Standard 34-2022 ANSI/ASHRAE Atlanta, GA, USA 2019
3. Shi W. Chang H. Zhou J. Mu B. Quan S. Pan L. Research Progress on CO2Transcritical Cycle Technology for Building Heating and Cooling Applications Buildings 2025 15 2952 10.3390/buildings15162952
4. Yang D. Li Y. Xie J. Wang J. Research and application progress of transcritical CO2refrigeration cycle system: A review Int. J. Low-Carbon Technol. 2022 17 245 256 10.1093/ijlct/ctab086
5. Song Y. Cui C. Yin X. Cao F. Advanced development and application of transcritical CO2refrigeration and heat pump technology—A review Energy Rep. 2022 8 7840 7869 10.1016/j.egyr.2022.05.233
6. Thanasoulas S. Rogstam J. Control strategy of two stage CO2heat recovery systems in ice rinks Proceedings of the 25th IIR International Congress of Refrigeration Montreal, QC, Canada 24–30 August 2019 10.18462/iir.icr.2019.1251
7. Austin B.T. Sumathy K. Transcritical carbon dioxide heat pump systems: A review Renew. Sustain. Energy Rev. 2011 15 4013 4029 10.1016/j.rser.2011.07.021
8. Zendehboudi A. Optimal discharge pressure and performance characteristics of a transcritical CO2heat pump system with a tri-partite gas cooler for combined space and water heating Renew. Energy 2024 226 120359 10.1016/j.renene.2024.120359
9. Yu B. Yang J. Wang D. Shi J. Chen J. An updated review of recent advances on modified technologies in transcritical CO2refrigeration cycle Energy 2019 189 116147 10.1016/j.energy.2019.116147
10. Tsimpoukis D. Syngounas E. Petsanas D. Mitsopoulos G. Anagnostatos S. Bellos E. Tzivanidis C. Vrachopoulos M.G. Energy and environmental investigation of R744 all-in-one configurations for refrigeration and heating/air conditioning needs of a supermarket J. Clean. Prod. 2021 279 123234 10.1016/j.jclepro.2020.123234
11. Maouris G. Escriva E.J.S. Acha S. Shah N. Markides C.N. CO2refrigeration system heat recovery and thermal storage modelling for space heating provision in supermarkets: An integrated approach Appl. Energy 2020 264 114722 10.1016/j.apenergy.2020.114722
12. Barta R.B. Ziviani D. Groll E.A. Design and commissioning of a modular multi-stage two-evaporator transcritical CO2test stand Int. J. Refrig. 2021 130 392 403 10.1016/j.ijrefrig.2021.05.033
13. Chen Y. Zou H. Dong J. Wu J. Xu H. Tian C. Experimental investigation on the heating performance of a CO2heat pump system with intermediate cooling for electric vehicles Appl. Therm. Eng. 2021 182 116039 10.1016/j.applthermaleng.2020.116039
14. Ierin V. Chen G. Volovyk O. Shestopalov K. Hybrid two–stage CO2transcritical mechanical compression–ejector cooling cycle: Thermodynamic analysis and optimization Int. J. Refrig. 2021 132 45 55 10.1016/j.ijrefrig.2021.09.012
15. Jadhav P. Agrawal N. A comparative study of flow characteristics of adiabatic spiral and helical capillary tube in a CO2transcritical system Int. J. Ambient Energy 2022 43 4594 4601 10.1080/01430750.2021.1913645
16. Lata M. Gupta D.K. Simulation and performance evaluation of trans-critical CO2refrigeration system with modified evaporative cooled finned tube gas cooler in Indian context Appl. Therm. Eng. 2021 186 116500 10.1016/j.applthermaleng.2020.116500
17. Pardiñas Á.Á. Jokiel M. Schlemminger C. Selvnes H. Hafner A. Modeling of a CO2-Based Integrated Refrigeration System for Supermarkets Energies 2021 14 6926 10.3390/en14216926
18. Cui C. Ren J. Rampazzo M. Song Y. Yin X. Cao F. Real-time energy-efficient operation of a dedicated mechanical subcooling based transcritical CO2heat pump water heater via multi-input single-output extreme seeking control Int. J. Refrig. 2022 144 76 89 10.1016/j.ijrefrig.2022.07.005
19. Casi Á. Aranguren P. Araiz M. Sanchez D. Cabello R. Astrain D. Experimental evaluation of a transcritical CO2refrigeration facility working with an internal heat exchanger and a thermoelectric subcooler: Performance assessment and comparative Int. J. Refrig. 2022 141 66 75 10.1016/j.ijrefrig.2022.05.024
20. Huang C. Li Z. Ye Z. Wang R. Performance analysis of two-stage CO2transcritical refrigeration cycles with absorption subcooling and mechanical recooling Int. J. Refrig. 2023 153 33 47 10.1016/j.ijrefrig.2023.05.023
21. Mohtaram S. Wu W. Castellanos H.G. Aryanfar Y. Al Mesfer M.K. Danish M. Irshad K. Enhancing energy efficiency and sustainability in ejector expansion transcritical CO2and lithium bromide water vapour absorption refrigeration systems Therm. Sci. Eng. Prog. 2023 43 101983 10.1016/j.tsep.2023.101983
22. Udroiu C.-M. Mota-Babiloni A. Giménez-Prades P. Barragán-Cervera Á. Navarro-Esbrí J. Thermodynamic evaluation of CO2for ultra-low temperature refrigeration Energy Convers. Manag. X 2023 20 100446 10.1016/j.ecmx.2023.100446
23. Sacasas D. Cuevas C. Vega J. Menéndez A. Borrajo R. Environmental and energetic impact of refrigeration systems using CO2(R744): A Cuban case study Sustain. Energy Technol. Assess. 2024 68 103873 10.1016/j.seta.2024.103873
24. Caliskan O. Sag N.B. Ersoy H.K. Thermodynamic, environmental, and exergoeconomic analysis of multi-ejector expansion transcritical CO2supermarket refrigeration cycles in different climate regions of Türkiye Int. J. Refrig. 2024 165 466 484 10.1016/j.ijrefrig.2024.05.006
25. Jiang J. Yang Q. Yin T. Zheng Z. Zhao Y. Liu G. Li L. Comparative thermodynamic study of CO2transcritical supermarket booster refrigeration system combined with vapor injection and parallel compression Int. J. Refrig. 2025 170 70 84 10.1016/j.ijrefrig.2024.11.007
26. Kitsopoulou A. Bellos E. Mitsopoulos G. Tzivanidis C. A benchmark comparative thermodynamic analysis of transcritical CO2heat pump configurations for heating purposes Therm. Sci. Eng. Prog. 2025 68 104200 10.1016/j.tsep.2025.104200
27. Larrondo-Sancho R. Sánchez D. Cabello R. Experimental improvement of a CO2transcritical cycle using parallel compressor and integrated subcooler Int. J. Refrig. 2025 175 63 73 10.1016/j.ijrefrig.2025.03.019
28. Li X. Zhang L. Xu X. Study on the effect of ejector on the performance of low temperature transcritical CO2two-stage compression refrigeration system Int. J. Refrig. 2025 175 299 313 10.1016/j.ijrefrig.2025.04.010
29. Wang Y. Li X. Guo Y. Dai J. Song J. He Q. Zhang Z. Xu Q. Yang J. Thermodynamic performance and CO2emission analysis of transcritical CO2two-stage compression refrigeration system with intermediate gas supplementation Energy 2025 320 135193 10.1016/j.energy.2025.135193
30. Chen Y. Song Y. Ren Z. Guan Y. Li S. Cao F. Dai X. Energetic performance and driving range investigation of the CO2indirect system with ejector used in vehicle thermal management Energy 2026 344 139906 10.1016/j.energy.2026.139906
31. Fang J. Zhang Y. Jia F. Yin X. Chen B. Cao F. Wang X. Quantitative evaluation of the evaporator configuration’s implications on the performance enhancement in CO2thermal management system for electric vehicle Int. J. Refrig. 2026 182 287 298 10.1016/j.ijrefrig.2025.11.029
32. Filho E.P.B. Hassan M.E. Bukharin N. Rana Z. Sakout A. Transcritical CO2refrigeration systems enhanced by ejector technology: State-of-the-art review Energy Convers. Manag. X 2026 29 101500 10.1016/j.ecmx.2025.101500
33. Sengupta A. Gullo P. Khorshidi V. Dasgupta M.S. Energy and economic comparison of various waste heat-driven cycles for integration with a transcritical R744 supermarket refrigeration system Appl. Therm. Eng. 2026 288 129555 10.1016/j.applthermaleng.2025.129555
34. Zong S. Zhang S. Jia F. Ren J. Wang Z. Chen E. Yin X. Cao F. Duan F. Range enhancement of electric vehicles with R744 thermal system under cold conditions Appl. Therm. Eng. 2026 284 129033 10.1016/j.applthermaleng.2025.129033
35. Peñarrocha I. Llopis R. Tárrega L. Sánchez D. Cabello R. A new approach to optimize the energy efficiency of CO2transcritical refrigeration plants Appl. Therm. Eng. 2014 67 137 146 10.1016/j.applthermaleng.2014.03.004
36. Nebot-Andrés L. Sánchez D. Calleja-Anta D. Cabello R. Llopis R. Experimental determination of the optimum working conditions of a commercial transcritical CO2refrigeration plant with a R-152a dedicated mechanical subcooling Int. J. Refrig. 2021 121 258 268 10.1016/j.ijrefrig.2020.10.002
37. Otón-Martínez R.A. Illán-Gómez F. García-Cascales J.R. Velasco F.J.S. Haddouche M.R. Impact of an internal heat exchanger on a transcritical CO2heat pump under optimal pressure conditions: Optimal-pressure performance of CO2heat pump with IHX Appl. Therm. Eng. 2022 215 118991 10.1016/j.applthermaleng.2022.118991
38. Wang W. Ye Z. Ren J. Li J. Cao F. Study on the mechanism of the optimal discharge pressure for a transcritical CO2system Int. J. Refrig. 2024 160 95 105 10.1016/j.ijrefrig.2024.01.021
39. Zheng Z. Song Y. Wang S. Yang X. Cao F. Yang T. Multi-factor coupling optimization of heat recovery effectiveness in a transcritical CO2heat pump Int. J. Refrig. 2024 167 201 213 10.1016/j.ijrefrig.2024.07.018
40. Jiang L. Song Y. Chen Y. Xie H. Ren J. Yin X. Cao F. Pang X. Bai G. Yang T. et al. The performance improvement and optimum control of the transcritical CO2air conditioning and heat pump system used in the high-speed railway vehicles Int. J. Refrig. 2026 182 49 60 10.1016/j.ijrefrig.2025.11.009
41. Sarkar J. Bhattacharyya S. Gopal M.R. Optimization of a transcritical CO2heat pump cycle for simultaneous cooling and heating applications Int. J. Refrig. 2004 27 830 838 10.1016/j.ijrefrig.2004.03.006
42. Cabello R. Sánchez D. Llopis R. Torrella E. Experimental evaluation of the energy efficiency of a CO2refrigerating plant working in transcritical conditions Appl. Therm. Eng. 2008 28 1596 1604 10.1016/j.applthermaleng.2007.10.026
43. Cao F. Song Y. Li M. Review on development of air source transcritical CO2heat pump systems using direct-heated type and recirculating-heated type Int. J. Refrig. 2019 104 455 475 10.1016/j.ijrefrig.2018.12.023
44. Liao S.M. Zhao T.S. Jakobsen A. A correlation of optimal heat rejection pressures in transcritical carbon dioxide cycles Appl. Therm. Eng. 2000 20 831 841 10.1016/S1359-4311(99)00070-8
45. Aprea C. Maiorino A. Heat rejection pressure optimization for a carbon dioxide split system: An experimental study Appl. Energy 2009 86 2373 2380 10.1016/j.apenergy.2009.03.006
46. Qi P.-C. He Y.-L. Wang X.-L. Meng X.-Z. Experimental investigation of the optimal heat rejection pressure for a transcritical CO2heat pump water heater Appl. Therm. Eng. 2013 56 120 125 10.1016/j.applthermaleng.2013.03.045
47. Wang S. Tuo H. Cao F. Xing Z. Experimental investigation on air-source transcritical CO2heat pump water heater system at a fixed water inlet temperature Int. J. Refrig. 2013 36 701 716 10.1016/j.ijrefrig.2012.10.011
48. Cecchinato L. Corradi M. Minetto S. A critical approach to the determination of optimal heat rejection pressure in transcritical systems Appl. Therm. Eng. 2010 30 1812 1823 10.1016/j.applthermaleng.2010.04.015
49. Liang C. Li X. Fang L. Nakazawa T. Tanaka T. Constructing year-round energy-efficient fresh air handling unit with exhaust air heat recovery using multi-condition design Energy Build. 2023 298 113574 10.1016/j.enbuild.2023.113574
50. Liu S. Ma G. Lv Y. Xu S. Review on heat pump energy recovery technologies and their integrated systems for building ventilation Build. Environ. 2024 248 111067 10.1016/j.buildenv.2023.111067
51. Calay R.K. Wang W.C. A hybrid energy efficient building ventilation system Appl. Therm. Eng. 2013 57 7 13 10.1016/j.applthermaleng.2013.03.042
52. Wallin J. Claesson J. Improving heat recovery using retrofitted heat pump in air handling unit with energy wheel Appl. Therm. Eng. 2014 62 823 829 10.1016/j.applthermaleng.2013.09.059
53. Siegele D. Ochs F. Feist W. Novel speed-controlled exhaust-air to supply-air heat pump combined with a ventilation system Appl. Therm. Eng. 2019 162 114230 10.1016/j.applthermaleng.2019.114230
54. Wang Z. Lu X. Wang G. Experimental and simulation performance optimization of an exhaust air heat recovery heat pump unit Int. J. Low-Carbon Technol. 2022 17 686 695 10.1093/ijlct/ctac047
55. Dimchev I. Terziev A. Ivanov M. Vassilev M. Climate change impact on the energy performance of an air handling unit with two-stage heat recovery E3S Web Conf. 2025 608 01009 10.1051/e3sconf/202560801009
56. Vlashki S. Preliminary analysis of transcritical R744 (CO2) heat pump Proceedings of the XXI Scientific Conference with International Participation FPEPM Sozopol, Bulgaria 18–21 September 2016 (In Bulgarian)
57. Vlashki S. Performance simulation of transcritical R744 (CO2) heat pump system Proceedings of the XXIV Scientific Conference with International Participation FPEPM Sozopol, Bulgaria 17–19 September 2019 (In Bulgarian)
58. Vlashki S. Integrated Transcritical Heat Pump System for Two-Stage Heat Regeneration (Bulgaria, Utility Model № BG/U/2019/4408). Bulgarian Patent Office 2019 Available online: https://portal.bpo.bg/bpo-registers/utility-models/view/BG_U_2019_4408 (accessed on 24 February 2026)
59. Klein S.A. Beckman W.A. Mitchell J.W. Duffie J.A. Duffie N.A. Freeman T.L. Duffy M.J. TRNSYS 17: A Transient System Simulation Program Solar Energy Laboratory, University of Wisconsin Madison, WI, USA 2010
60. Herrmann S. Kretzschmar H.-J. Gatley D.P. ASHRAE Library of Humid Air Psychrometric & Transport Property (LibHuAirProp) Functions for 64-bit MATLAB, I-P and SI Units ASHRAE Atlanta, GA, USA 2011
61. ASHRAE Component Balancing in Refrigeration Systems ASHRAE Handbook—Refrigeration ASHRAE Atlanta, GA, USA 2022
62. Klingenburg GmbH Rotary Heat Exchanger Selection Software Version 5.0 Klingenburg GmbH Gladbeck, Germany 2017
63. ANSI/ASHRAE Standard 55-2017 Thermal Environmental Conditions for Human Occupancy ASHRAE Atlanta, GA, USA 2017
64. EN 15251:2007 Indoor Environmental Input Parameters for Design and Assessment of Energy Performance of Buildings Addressing Indoor Air Quality, Thermal Environment, Lighting and Acoustics IEA Paris, France 2007
65. EN 16798-1:2019 Energy Performance of Buildings—Ventilation for Buildings—Part 1: Indoor Environmental Input Parameters for Design and Assessment of Energy Performance of Buildings Addressing Indoor Air Quality, Thermal Environment, Lighting and Acoustics—Module M1-6 iTeh Standard San Francisco, CA, USA 2019
66. Zeller M. DX-Evaporator Version 2016-05-10 ZCS Ittigen, Switzerland 2016
67. Breidenbach K. Der Kälteanlagenbauer Band 1: Grundkenntnisse VDE Verlag GmbH Berlin/Offenbach, Germany 2010
68. Zeller M. Condenser Version 2015-10-21 ZCS Ittigen, Switzerland 2016
69. Zeller M. CO2Sup Crit Cooler Version 2014-10-26 ZCS Ittigen, Switzerland 2016
70. SWEP SSP G7 Version 7.0.3.56 SWEP Landskrona, Sweden 2016
71. Danfoss Transcritical CO2Booster System: How to Control the System Available online: https://www.danfoss.com/co2 (accessed on 10 May 2026)
72. Dr Wolf Srl Dorin Software Version 15.07 Dorin S.p.A. Fiesole, Italy 2015
73. Klein S.A. Reindl D.T. Brownell K. Refrigeration system performance using liquid-suction heat exchangers Int. J. Refrig. 2000 23 588 596 10.1016/S0140-7007(00)00008-6
74. Copeland Discharge Temperature Limit for Copeland Compressors Available online: https://copeland.custhelp.com/app/answers/detail/a_id/978/~/discharge-temperature-limit-for-copeland-compressors (accessed on 12 July 2026)
75. Copeland Maximum Discharge Line Temperature Protection for Copeland Scroll Variable Speed Compressors Available online: https://copeland.custhelp.com/app/answers/detail/a_id/3125/~/maximum-discharge-line-temperature-protection-for-copeland-scroll-variable (accessed on 12 July 2026)
76. Copeland Recommended Temperature Limit for the Discharge Line to Avoid Oil Breakdown Available online: https://copeland.custhelp.com/app/answers/detail/a_id/4578/~/recommended-temperature-limit-for-the-discharge-line-to-avoid-oil-breakdown (accessed on 12 July 2026)

Issue